Surface Analysis

67 %
33 %
Information about Surface Analysis

Published on September 30, 2007

Author: luyenkimnet



Phân tích hình thái và nguyên tố của vật liệu màng

LEDN-02 Analysis Techniques Sample Probe Response Modified Probe Probe : photo Response : photo electron electron ion ion phonon phonon

Analysis Techniques phonon photo photo XRF, TXRF, FTIR, Raman electron electron ion ion phonon SIMS, RBS , ISS, GDMS ESCA EDS PIXE, GDOS SEM, TEM, AES, EELS LAMMA LEDN-03 Scanning Acoustic Microscopy

LEDN-004 Analysis Techniques Elemental Molecular Surface ( <10 Å) Thin film ( <100 Å - 1  m) Bulk ( > 10  m) Types of information provided by chemical analysis

LEDN-005 Surface and Thin film Analysis Surface Thin Film Elemental Molecular TXRF EDS RBS AES ESCA SIMS

100% 100 ppm 1% 1 ppm XRF ESCA AES RBS SIMS EDX 100Å 10 µm 0.1 µm 1 µm 1 µm 0.1 µm 10 µm 100 µm 1 mm VD D E SENSITIVITY SPATIAL RESOLUTION QUANTITATION DEPTH RESOLUTION LEDN-006 SIMS vs. Other Techniques

LEDN-07 Analysis Principle Excitation Photoelectron E b = h  -E k -  Relaxtation ESCA EDS, XRF AES Auger electron KL 1 L 2,3 K (1s) L 1 (2s) L 2,3 (2s) Atom Ion e- h  h 

LEDN-08 Analysis Principle X-ray fluorescence (surface) Incident X-rays TRXF Depth information determined either by excitation depth or by escape depth 10-100 Å electron escape depth 1  m Electron excitation depth Auger electrons (surface) X-ray fluorescence Primary Electrons 10-100 Å electron escape depth 100-1000  m X-ray excitation depth photoelectrons (surface) X-ray fluorescence Incident X-rays

LEDN-09 Absorbed molecules Sputtered atoms SIMS Principle Sputtering event + + + Primary ions (~10 keV) Sample atoms + + - + + Secondary ions Mixing range (~100 Å) Escape range (~10 Å) Desorbed molecular ions


Magnetic sector Quadrupole Time of Flight LEDN-11 SIMS Instrument Type r = k/B(m/q) 1/2 M-  M M M+  M Vo(t) = Vc+Vs cos  t t-  t ~ M-  M t ~ M t+  t ~ M+  M ion pulse Detection & Registration m/q ~ B m/q ~ V(f) m/q ~ t

 << A  = A Static SIMS Dynamic SIMS Primary ion dose <1E12 ions/cm2 >1E12 ions/cm2 Information Chemical Elemental Analysis Only surface Depth profile Instrument TOF & Quad Magnetic & Quad Ion damage section,  Desorption area, D Bombarded surface, A LEDN-12 Dynamic vs. Static SIMS primary ion ion: elementa l information ion: molecular information

LEDN-13 Comparison of SIMS Instruments Magnetic Sector Quadrupole Time of Flight Transmission High (~10 -1 ) Low (~10 -3 ) High (~10 -1 ) Mass range Low (< 500) Low (< 600) Unlimited Mass resolution High ~ 10000 Low ~ 500 High ~ 10000 Detection speed Low High Quasi-parallel Charge compensation Difficult Easy Easy Analysis modes Bulk analysis Depth profiling (100Å-100  m) Imaging Bulk analysis Depth profiling (0Å-10  m) Imaging Surface Analysis Depth profiling (0Å-1  m) Imaging

Analytical Condition LEDN-14 Oxygen bombardment & Positive ions Cs bombardment & Negative ions Cs bombardment & Oxygen bombardment

LEDN-15 Detection Limits (atoms/cm3) in InP, GaAs, GaN For electropositive elements SIMS Detection Limit

LEDN-16 Detection Limits (atoms/cm3) in GaAs,InP and GaN For electronegative elements SIMS Detection Limit

Depth (  m) 1E13 at/cm3 LEDN-17 High Mass Resolution Analysis for P in Si High Sensitivity Concentration(at/cm3) P implantation in Si (2E12 atoms/cm2, 300 keV)

LEDN-18 Depth profiling of Multi-Quantum wells InGaAsP/InGaAs SIMS Depth Resolution Lz = 110 Å Lz = 125 Å

SiC fiber in a Ti matrix (V-doped) LEDN-19 Ti C Si V 50  m Ga + primary ion (30 keV, 50 pA) Ti + : 10s; Si + : 200s; V + : 100s; C + : 200s SIMS Image Analysis

SIMS Analysis for GaN LEDs LEDN-20 Enhance production yield Wafer Control LED wafers Test wafers Purity control (C,H,O,metals) Doping control (Si, Mg) Layer thickness (Growth rate) Interface quality Film composition (AlGaN,InGaN) SIMS analysis Calibration & Optimization of Growth GaN Epitaxy Growth Failure analysis Reverse engineering LED dies Reduce R&D cycle time

Enhance production yield

LED wafers

Test wafers

Purity control (C,H,O,metals)

Doping control (Si, Mg)

Layer thickness (Growth rate)

Interface quality

Film composition (AlGaN,InGaN)

Reduce R&D cycle time

SIMS for AlInGaP LED LEDN-21 Depth (micron) Concentration (atoms/cm 3 ) AlInGaP

LEDN-22 SIMS for GaN LED Depth (micron) Concentration (atoms/cm 3 ) InGaN

SIMS for AlInGaP LD LEDN-23 Depth (micron) Concentration (atoms/cm 3 ) AlInGaP

SIMS for AlGaAs VCSEL LEDN-24 Depth (micron) Concentration (atoms/cm 3 ) VCSEL

SIMS for LED dies LEDN-25 GaN LED die SIMS craters AlInGaP LED die SIMS craters Doping concentration and distribution Undesirable Impurities Layer structure control Failure analysis Epi-layer structure p- and n-type metal stacks Passivation layers Reverse engineering

Doping concentration and distribution

Undesirable Impurities

Layer structure control

Epi-layer structure

p- and n-type metal stacks

Passivation layers

PL on the beveled surface SIMS profile Comparison between PL and SIMS LEDN-26 Composition Analysis by SIMS Al x Ga 1-x As composition by MCs + technique A B C D

Composition Analysis by Auger LEDN-27 Depth profiling of the top layers of GaN die

Add a comment

Related presentations

Related pages

Bruker Surface Analysis group - Bruker Corporation: Bruker

Bruker provides technology for surface analysis & surface measurement. Learn about our extensive suite of application-focused instrumentation.
Read more

Surface weather analysis - Wikipedia, the free encyclopedia

Surface weather analysis is a special type of weather map that provides a view of weather elements over a geographical area at a specified time based on ...
Read more

North American Surface Analysis - Weather Prediction Center

Current Surface Analysis. North America / With Surface Observations Click on above map for full view. [Black and White Image] North America ...
Read more

Surface Analysis - John T. Grant

Information about short courses in surface analysis, Auger electron spectroscopy, x-ray photoelectron spectroscopy, depth profiling, AES, XPS, ESCA, SIMS ...
Read more

List of materials analysis methods - Wikipedia, the free ...

μSR - see Muon spin spectroscopy; χ - see Magnetic susceptibility; A. Analytical ultracentrifugation - Analytical ultracentrifugation; AAS - Atomic ...
Read more

Intellicast - Surface Analysis in Russia

Description: The Global Surface Analysis image shows current frontal, high, and low positions for sectors of the world. A surface weather analysis is a ...
Read more

Surface Analysis: ebook jetzt bei als Download

eBook Shop: Surface Analysis als Download. Jetzt eBook sicher bei Weltbild runterladen & bequem mit Ihrem Tablet oder eBook Reader lesen.
Read more

UK Surface Analysis Forum

Welcome. The UK Surface Analysis Forum is a society for scientists from academia and industry with a common interest in the techniques and applications of ...
Read more

surface analysis | chemistry |

Surface analysis, in analytical chemistry, the study of that part of a solid that is in contact with a gas or a vacuum. When two phases of matter are in ...
Read more

Intellicast - Current Surface Analysis in United States

The Current Surface Analysis map shows current weather conditions, including frontal and high/low pressure positions, satellite infrared (IR) cloud cover ...
Read more